AlN-based BAW resonators with CNT electrodes for gravimetric biosensing

SENSORS AND ACTUATORS B-CHEMICAL

卷:160

Article

Garcia-Gancedo, L.¹  Zhu, Z.¹  Iborra, E.²  Clement, M.²  Olivares, J.²  Flewitt, A. J.¹  Milne, W. I.¹  Ashley, G. M.³  Luo, J. K.³  Zhao, X. B.⁴  Lu, J. R.⁴ 

[1] Univ Cambridge, Elect Engn Div, Cambridge CB3 0FA, England

[2] Univ Politecn Madrid, Grp Microsistemas & Mat Elect, Madrid, Spain

[3] Univ Bolton, IMRI, Bolton, England

[4] Univ Manchester, Sch Phys & Astron, Manchester, Lancs, England

关键词: Biosensor;    Carbon nanotube (CNT);    Aluminum nitride (AlN);    Bulk acoustic wave resonator (BAW);    Gravimetric biosensor;   

DOI  :  10.1016/j.snb.2011.09.083

来源: Elsevier

【 摘 要 】

Solidly mounted resonators (SMRs) with a top carbon nanotubes (CNTs) surface coating that doubles as an electrode and as a sensing layer have been fabricated. The influence of the CNTs on the frequency response of the resonators was studied by direct comparison to identical devices with a top metallic electrode. It was found that the CNTs introduced significantly less mass load on the resonators and these devices exhibited a greater quality factor, Q (>2000, compared to similar to 1000 for devices with metal electrodes), which increases the gravimetric sensitivity of the devices by allowing the tracking of smaller frequency shifts. Protein solutions with different concentrations were loaded on the top of the resonators and their responses to mass-load from physically adsorbed coatings were investigated. Results show that resonators using CNTs as the top electrode exhibited a higher frequency change for a given load (similar to 0.25 MHz cm(2) ng(-1)) compared to that of a metal thin film electrode (similar to 0.14 MHz cm(2) ng(-1)), due to the lower mass of the CNT electrodes and their higher active surface area compared to that of a thin film metal electrode. It is therefore concluded that the use of CNT electrodes on resonators for their use as gravimetric biosensors is a significant improvement over metallic electrodes that are normally employed. (C) 2011 Elsevier B.V. All rights reserved.

【 授权许可】

Free