Effects of Time, Heat, and Oxygen on K Basin Sludge Agglomeration, Strength, and Solids Volume

Delegard, Calvin H. ; Sinkov, Sergey I. ; Schmidt, Andrew J. ; Daniel, Richard C. ; Burns, Carolyn A.

关键词: AR FACILITIES;    AGGLOMERATION;    CONTAINERS;    CORROSION;    HEATING;    MANAGEMENT;    MECHANICAL PROPERTIES;    MIXTURES;    OXIDATION;    OXYGEN;    PARTIAL PRESSURE;    RECRYSTALLIZATION;    SHEAR PROPERTIES;    SLUDGES;    STORAGE;    URANINITES;    URANIUM;    VANES;    WASTE STORAGE;    WIPP;   

DOI  :  10.2172/1004501
RP-ID  :  PNNL-20100
RP-ID  :  53451-RPT13
PID  :  OSTI ID: 1004501
Others  :  Other: 830403000
Others  :  TRN: US1101490

学科分类：核能源与工程

美国|英语

来源: SciTech Connect

【 摘 要 】

Sludge disposition will be managed in two phases under the K Basin Sludge Treatment Project. The first phase is to retrieve the sludge that currently resides in engineered containers in the K West (KW) Basin pool at ~10 to 18?��C. The second phase is to retrieve the sludge from interim storage in the sludge transport and storage containers (STSCs) and treat and package it in preparation for eventual shipment to the Waste Isolation Pilot Plant. The work described in this report was conducted to gain insight into how sludge may change during long-term containerized storage in the STSCs. To accelerate potential physical and chemical changes, the tests were performed at temperatures and oxygen partial pressures significantly greater than those expected in the T Plant canyon cells where the STSCs will be stored. Tests were conducted to determine the effects of 50?��C oxygenated water exposure on settled quiescent uraninite (UO2) slurry and a full simulant of KW containerized sludge to determine the effects of oxygen and heat on the composition and mechanical properties of sludge. Shear-strength measurements by vane rheometry also were conducted for UO2 slurry, mixtures of UO2 and metaschoepite (UO3???2H2O), and for simulated KW containerized sludge. The results from these tests and related previous tests are compared to determine whether the settled solids in the K Basin sludge materials change in volume because of oxidation of UO2 by dissolved atmospheric oxygen to form metaschoepite. The test results also are compared to determine if heating or other factors alter sludge volumes and to determine the effects of sludge composition and settling times on sludge shear strength. It has been estimated that the sludge volume will increase with time because of a uranium metal ??? uraninite ??? metaschoepite oxidation sequence. This increase could increase the number of containers required for storage and increase overall costs of sludge management activities. However, the volume might decrease because of decreases in the water-volume fraction caused by sludge solid reactions, compaction, or intergrowth and recrystallization of metaschoepite. In that case, fewer STSCs may be needed, but the shear strength would increase, and this could challenge recovery by water jet erosion and require more aggressive retrieval methods. Overall, the tests described herein indicate that the settled solids volume remains the same or decreases with time. The only case for which the sludge solids volumes increase with time is for the expansion factor attendant upon the anoxic corrosion of uranium metal to produce UO2 and subsequent reaction with oxygen to form equimolar UO2.25 and UO3???2H2O.