Production of novel applicable derivatives from biodiesel glycerin

Green Processing and Synthesis

Isenmann Armin Franz¹  Abrishamkar Amin²  Abrishamkar Afshin³ 

[1] Department of Chemistry, Federal Center for Technological Education of Minas Gerais (CEFET-MG), Av. Amazonas 1193, 35.183-006 Timóteo, Brazil;Department of Mechanical Engineering, Sharif University of Technology (SUT), Azadi St., 11365–11155 Tehran, Iran;Institute for Chemical and Bioengineering, Department of Chemistry and Applied Biosciences, Swiss Federal Institute of Technology Zurich (ETH Zurich), Vladimir-Prelog-Weg 1, 8093 Zurich, Switzerland;

关键词: biodiesel production;    catalytic reaction;    esterification reaction;    glycerin derivatives;    reaction optimization;   

DOI  :  10.1515/gps-2017-0028

来源: DOAJ

【 摘 要 】

Glycerin (glycerol) is a co-product of biodiesel production that is widely produced and is available at a low cost. To date, various applications have been investigated and introduced for biodiesel glycerin. In this study, a number of valuable products were produced using biodiesel glycerin and formic acid as the main reactants. Allyl alcohol is one of the valuable chemicals produced from glycerin monoformate. Efficient production of this product requires successful completion of the first section of the reaction, which is an equilibrium reaction. The highest feasible yield achieved was about 83% (based on the consumption of formic acid) at 120–140°C without the addition of any catalysts. Also, the esterification reaction was further investigated at room temperature, where the equilibrium state was reached with a yield of 55% after only 4 h. Moreover, the addition of urea to the reaction with the aim of producing the other two side products, i.e. diformyl urea and glycerin carbonate, in addition to glycerin monoformate, was studied. The results showed that considerable amounts of applicable byproducts, e.g. formamid, are also produced, making the process even more economical.

【 授权许可】

Unknown