Effects of CO 2 limitation on the metabolism of Pseudoclostridium thermosuccinogenes

BMC Microbiology

article

Koendjbiharie, Jeroen Girwar¹  Post, Wilbert Berend²  Palmer, Martí Munar²  van Kranenburg, Richard² 

[1] Corbion;Laboratory of Microbiology, Wageningen University

关键词: CO 2 limitation;    Pseudoclostridium thermosuccinogenes;    Fermentation products;    Succinic acid;    Transcriptomics;    Redox balance;    Batch fermentation;    Chemostat;   

DOI  :  10.1186/s12866-020-01835-2

学科分类：放射科、核医学、医学影像

来源: BioMed Central

【 摘 要 】

Bio-based succinic acid holds promise as a sustainable platform chemical. Its production through microbial fermentation concurs with the fixation of CO2, through the carboxylation of phosphoenolpyruvate. Here, we studied the effect of the available CO2 on the metabolism of Pseudoclostridium thermosuccinogenes, the only known succinate producing thermophile. Batch cultivations in bioreactors sparged with 1 and 20% CO2 were conducted that allowed us to carefully study the effect of CO2 limitation. Formate yield was greatly reduced at low CO2 concentrations, signifying a switch from pyruvate formate lyase (PFL) to pyruvate:ferredoxin oxidoreductase (PFOR) for acetyl-CoA formation. The corresponding increase in endogenous CO2 production (by PFOR) enabled succinic acid production to be largely maintained as its yield was reduced by only 26%, thus also maintaining the concomitant NADH re-oxidation, essential for regenerating NAD+ for glycolysis. Acetate yield was slightly reduced as well, while that of lactate was slightly increased. CO2 limitation also prompted the formation of significant amounts of ethanol, which is only marginally produced during CO2 excess. Altogether, the changes in fermentation product yields result in increased ferredoxin and NAD+ reduction, and increased NADPH oxidation during CO2 limitation, which must be linked to reshuffled (trans) hydrogenation mechanisms of those cofactors, in order to keep them balanced. RNA sequencing, to investigate transcriptional effects of CO2 limitation, yielded only ambiguous results regarding the known (trans) hydrogenation mechanisms. The results hinted at a decreased NAD+/NADH ratio, which could ultimately be responsible for the stress observed during CO2 limitation. Clear overexpression of an alcohol dehydrogenase (adhE) was observed, which may explain the increased ethanol production, while no changes were seen for PFL and PFOR expression that could explain the anticipated switch based on the fermentation results.

【 授权许可】

CC BY|CC0