Biodiesel production from ethanolysis of palm oil using deep eutectic solvent (DES) as co-solvent

29th Symposium of Malaysian Chemical Engineers 2016

Manurung, R.^1 ; Winarta, A.^1 ; Taslim^1 ; Indra, L.^1

Department of Chemical Engineering, Engineering Faculty, University of Sumatera Utara, Medan, Indonesia^1

关键词: Biodiesel production;    Catalyst concentration;    Deep eutectic solvents;    Hydrogen bond donors;    International standards;    Quaternary ammonium salt;    Reaction equilibrium;    Volatile organic solvents;   

Others  :  https://iopscience.iop.org/article/10.1088/1757-899X/206/1/012023/pdf
DOI  :  10.1088/1757-899X/206/1/012023

来源: IOP

【 摘 要 】

Biodiesel produced from ethanolysis is more renewable and have better properties (higher oxidation stability, lower cloud and pour point) compared to methanolysis, but it has a disadvantage such as complicated purification. To improve ethanolysis process, deep eutectic solvent (DES) can be prepared from choline chloride and glycerol and used as co-solvent in ethanolysis. The deep eutectic solvent is formed from a quaternary ammonium salt (choline chloride) and a hydrogen bond donor (Glycerol), it is a non-toxic, biodegradable solvent compared to a conventional volatile organic solvent such as hexane. The deep eutectic solvent is prepared by mixing choline chloride and glycerol with molar ratio 1:2 at temperature 80 °C, stirring speed 300 rpm for 1 hour. The DES is characterized by its density and viscosity. The ethanolysis is performed at a reaction temperature of 70 °C, ethanol to oil molar ratio of 9:1, potassium hydroxide as catalyst concentration of 1.2 wt. DES as co-solvent with concentration 0.5 to 3 wt. stirring speed 400 rpm, and a reaction time 1 hour. The obtained biodiesel is then characterized by its density, viscosity, and ester content. The oil - ethanol phase condition is observed in the reaction tube. The oil - ethanol phase with DES tends to form meniscus compared to without DES, showed that oil and ethanol become more slightly miscible, which favors the reaction. Using DES as co-solvent in ethanolysis showed increasing in yield and easier purification. The esters properties meet the international standards ASTM D6751, with the highest yield achieved 83,67 with 99,77 conversion at DES concentration 2 . Increasing DES concentration above 2 in ethanolysis decrease the conversion and yield, because of the excessive glycerol in the systems makes the reaction equilibrium moves to the reactant side.