Characterization and recovery of rare earth elements and other critical metals (Co, Cr, Li, Mn, Sr, and V) from the calcination products of a coal refuse sample

FUEL

卷:267

Article

Zhang, Wencai¹  Honaker, Rick² 

[1] Virginia Polytech Inst & State Univ, Dept Min & Minerals Engn, Blacksburg, VA 24061 USA

[2] Univ Kentucky, Dept Min Engn, Lexington, KY 40506 USA

关键词: Bituminous coal;    Rare earth elements;    Critical metals;    Calcination;    Leachability;    Sequential chemical extraction;   

DOI  :  10.1016/j.fuel.2020.117236

来源: Elsevier

【 摘 要 】

The impacts of calcination on the leaching recovery of rare earth elements (REEs) and other critical metals from a Baker seam coal refuse material were investigated in this study. Acid leaching test results showed that leaching recovery of the REEs, especially the light REEs, was increased significantly from around 24% to 80-90% after calcination under 600-750 degrees C for two hours. By considering the major element leaching kinetics and the mineralogical changes of the dominant minerals caused by calcination, two mechanisms were proposed for the improved leaching performance: (1) decomposition of difficult-to-dissolve REE-bearing minerals into soluble forms; and (2) liberation of REE-bearing minerals encapsulated in clays after calcination due to the dehydration and disintegration of the layered clay structure. Sequential chemical extraction tests showed that a significant fraction (around 75%) of the REEs in the raw material were present in an insoluble form. After calcination under proper temperatures (600-800 degrees C), the majority of the insoluble light REEs (LREEs) were converted into soluble forms. Changes in the modes of occurrence of the LREEs and phosphorous based on leaching rate and sequential leaching correlated well as a function of the calcination temperature. This finding in addition to SEM-EDX results tends to indicate the potential that the LREEs occur primarily as rare earth phosphates such as monazite in the untreated coal refuse material. The acid leaching and sequential chemical extraction results show that co-extraction of REEs and other critical metals such as Co, Mn, and Li is possible using a calcination-acid leaching procedure.

【 授权许可】

Free