Perspectives on carbon materials as powerful catalysts in continuous anaerobic bioreactors

WATER RESEARCH

卷:101

Article

Pereira, R. A.¹  Salvador, A. F.¹  Dias, P.¹  Pereira, M. F. R.²  Alves, M. M.¹  Pereira, L.¹ 

[1] Univ Minho, Ctr Engn Biol, Campus Gualtar, P-4710057 Braga, Portugal

[2] Univ Porto, Fac Engn, Dept Engn Quim, Lab Catalise & Mat LCM,Lab Assoc LSRE LCM, Rua Dr Roberto Frias, P-4200465 Oporto, Portugal

关键词: Anaerobic bioreduction;    Carbon materials;    Microbial diversity;    Redox mediators;    UASB bioreactor;   

DOI  :  10.1016/j.watres.2016.06.004

来源: Elsevier

【 摘 要 】

The catalytic effect of commercial microporous activated carbon (AC) and macroporous carbon nano tubes (CNT) is investigated in reductive bioreactions in continuous high rate anaerobic reactors, using the azo dye Acid Orange 10 (AO10) as model compound as electron acceptor and a mixture of VFA as electron donor. Size and concentration of carbon materials (CM) and hydraulic retention time (HRT) are assessed. CM increased the biological reduction rate of AO10, resulting in significantly higher colour removal, as compared to the control reactors. The highest efficiency, 98%, was achieved with a CNT diameter (d) lower than 0.25 mm, at a CNT concentration of 0.12 g per g of volatile solids (VS), a HRT of 10 h and resulted in a chemical oxygen demand (COD) removal of 85%. Reducing the HRT to 5 h, colour and COD removal in CM-mediated bioreactors were above 90% and 80%, respectively. In the control reactor, thought similar COD removal was achieved, AO10 decolourisation was just approximately 20%, demonstrating the ability of CM to significantly accelerate the reduction reactions in continuous bioreactors. AO10 reduction to the correspondent aromatic amines was proved by high performance liquid chromatography (HPLC). Colour decrease in the reactor treating a real effluent with CNT was the double comparatively to the reactor operated without CNT. The presence of AC in the reactor did not affect the microbial diversity, as compared to the control reactor, evidencing that the efficient reduction of AO10 was mainly due to AC rather than attributed to changes in the composition of the microbial communities. (C) 2016 Elsevier Ltd. All rights reserved.

【 授权许可】

Free