Antifouling grafting of ceramic membranes validated in a variety of challenging wastewaters

WATER RESEARCH

卷:104

Article

Mustafa, Ghulam^1,2  Wyns, Kenny¹  Buekenhoudt, Anita¹  Meynen, Vera^1,2 

[1] VITO NV Flemish Inst Technol Res NV, Boeretang 200, B-2400 Mol, Belgium

[2] Univ Antwerp, Dept Chem, Lab Adsorpt & Catalysis LADCA, CDE, Univ Pl 1, B-2610 Antwerp, Belgium

关键词: Pulp and paper waste effluents;    Olive oil wastewater;    Oil/gas produced water;    Ceramic membranes;    Membrane fouling;    Antifouling grafting;   

DOI  :  10.1016/j.watres.2016.07.057

来源: Elsevier

【 摘 要 】

Compared to traditional separation and purification techniques, membrane filtration is particularly beneficial for the treatment of wastewater streams such as pulp and paper mill effluents (PPME), olive oil wastewater (OOWW) and oil/gas produced water (PW). However, severe membrane fouling can be a major issue. In this work, the use of ceramic membranes and the potential for the broad applicability of a recently developed antifouling grafting was evaluated to tackle this issue. To this end, the fouling behavior of native and grafted membranes was tested in the selected difficult wastewater streams, both in dead-end and in cross-flow mode. In addition, the quality of the produced permeate water was determined to assess the overall performance of the investigated membranes for reuse or recycling of the treated wastewater. The obtained results show that grafting significantly enhances the antifouling tendency of the ceramic membranes. Particularly, the membrane grafted with methyl groups using the Grignard technique (MGR), showed in all cases no or negligible fouling as compared to the native membrane. As a consequence, the process flux or filtration capacity of the MGR membrane in cross-flow is always higher and more stable than the native membrane, even though the grafting lowers the pure water flux. Hence, the inert character of the MGR membrane is repeatedly proven and shown to be broadly applicable and generic for anti-fouling, without loss in permeate quality. Moreover, in case of OOWW, the quality of the MGR permeate is even better than that of the native membrane due to its lower fouling. All results can be explained taking into account the physico-chemical properties of foulants and membranes, as shown in previous work. In conclusion, the use of MGR membranes could provide an optimum economical solution for the treatment of the selected challenging wastewaters. (C) 2016 Elsevier Ltd. All rights reserved.

【 授权许可】

Free