Use of non-growing Lactococcus lactis cell suspensions for production of volatile metabolites with direct relevance for flavour formation during dairy fermentations

Microbial Cell Factories

Research

Willem M de Vos¹  Bert van de Bunt²  Peter A Bron³  Lolke Sijtsma⁴  Jeroen Hugenholtz⁵ 

[1] Laboratory of Microbiology, Wageningen University, Wageningen, The Netherlands;Department Veterinary Biosciences, University of Helsinki, Helsinki, Finland;TI Food and Nutrition, Wageningen, The Netherlands;NIZO food research, Ede, The Netherlands;TI Food and Nutrition, Wageningen, The Netherlands;NIZO food research, Ede, The Netherlands;The Kluyver Centre for Genomics of Industrial Fermentations/NCSB, Delft, The Netherlands;TI Food and Nutrition, Wageningen, The Netherlands;The Kluyver Centre for Genomics of Industrial Fermentations/NCSB, Delft, The Netherlands;Wageningen UR Food & Biobased Research, Wageningen, The Netherlands;University of Amsterdam, Swammerdam Institute of Life Sciences, Science park 904, 1090 GE, Amsterdam, The Netherlands;

关键词: Flavour;    Lactococcus lactis;    Lactic acid bacteria;    Non-growing;    Amino acid metabolism;    Screening method;    Cheese;   

DOI  :  10.1186/s12934-014-0176-2

 received in 2014-06-13, accepted in 2014-11-28,  发布年份 2014

来源: Springer

【 摘 要 】

BackgroundLactococcus lactis is a lactic acid bacterium that has been used for centuries in the production of a variety of cheeses, as these bacteria rapidly acidify milk and greatly contribute to the flavour of the fermentation end-products. After a short growth phase during cheese ripening L. lactis enters an extended non-growing state whilst still strongly contributing to amino acid-derived flavour formation. Here, a research approach is presented that allows investigation of strain- and amino acid-specific flavour formation during the non-growing state.ResultsNon-growing cells of five selected L. lactis strains were demonstrated to degrade amino acids into flavour compounds that are relevant in food fermentations and differs greatly from production of flavour compounds using growing cells. As observed earlier in other research set-ups and with other microorganisms, addition of NADH, α-ketoglutarate and pyridoxal-5-phosphate was demonstrated to be essential for optimal flavour formation, suggesting that intracellular pools of these substrates are too low for the significant production of the flavour compounds. Production of flavours during the non-growing phase strongly depends on the individual amino acids that were supplied, on the presence of other amino acids (mixtures versus single compounds), and on the strain used. Moreover, we observed that the plasmid-free model strains L. lactis MG1363 and IL1403 produce relatively low amounts of flavour components under the various conditions tested.ConclusionsBy using this simplified and rapid approach to study flavour formation by non-growing lactic acid bacteria, lengthy ripening periods are no longer required to assess the capacity of strains to produce flavours in the long, non-growing state of dairy fermentation. In addition, this method also provides insight into the conversion of single amino acids versus the conversion of a mixture of amino acids as produced during protein degradation. The generated results are complementary to earlier generated datasets using growing cells, allowing assessment of the full flavour forming potential of strains used as starter cultures in industrial food fermentation processes.

【 授权许可】

Unknown   
© van de Bunt et al.; licensee BioMed Central Ltd. 2014. This article is published under license to BioMed Central Ltd. This is an Open Access article distributed under the terms of the Creative Commons Attribution License (http://creativecommons.org/licenses/by/4.0), which permits unrestricted use, distribution, and reproduction in any medium, provided the original work is properly credited. The Creative Commons Public Domain Dedication waiver (http://creativecommons.org/publicdomain/zero/1.0/) applies to the data made available in this article, unless otherwise stated.