Fischer Tropsch water composition study from distillation process in gas to liquid technology with ASPEN simulation

Case Studies in Chemical and Environmental Engineering

Calvin Jose Jol¹  Nazeri Abdul Rahman²  Verawaty Ismail³  Dyg Sharifah Rozellia Kamel Sharif³  Allene Albania Linus³ 

[1] Department of Chemical Engineering and Energy Sustainability, Faculty of Engineering, Universiti Malaysia Sarawak, Kota Samarahan, Sarawak, Malaysia;Corresponding author.;Department of Chemical Engineering and Energy Sustainability, Faculty of Engineering, Universiti Malaysia Sarawak, Kota Samarahan, Sarawak, Malaysia;

关键词: Fischer-tropsch;    Distillation;    Wastewater;    Aspen;    Quality;   

DOI  :  

来源: DOAJ

【 摘 要 】

Fischer-Tropsch is a polymerization reaction that produces a long chain of hydrocarbons such as linear paraffin, linear olefins, and water. Water is a by-product of Fischer Tropsch synthesis that contains impurities such as olefins and oxygen-containing compounds. Therefore, this study aims to analyze chemical oxygen demand (COD) level of Fischer Tropsch water from the distillation process by using Aspen simulation. Correspondingly, this study designs a Fischer Tropsch water distillation unit that can recover 1.2% of volatile organic compounds from the wastewater. In addition, this study has identified three (3) sections in the Fischer Tropsch water distillation unit which are distillation, recovery, and neutralization. Following this, a steady-state model is simulated through Aspen software with UNIQUAC-HOC as the thermodynamic model. The developed simulation model was found to be less than a 10% deviation as compared to the actual data from the natural gas processing plant located in Sarawak. Overall, the simulated distillation unit shows that 2100 tons of Fischer Tropsch water that can be treated at 120 ​°C and 2.21 ​bar per day. The overhead product is an enriched volatile organic compounds stream while the bottom product is an enriched water stream. For this study, the processed water quality from distillation column has been compared with both stripped water quality in natural gas processing and National Water Standard Quality. Consequently, the comparison shows that the chemical oxygen demand of processed water level is at 600 ​ppm after distillation which follows the stripped water quality in natural gas processing, however, requires post-water treatment before being discharge to the surface water sources.

【 授权许可】

Unknown