Redox Potential as a Means to Control the Treatment of Slurry to Lower H2S Emissions

Sensors

Maibritt Hjorth¹  Christina Ø Pedersen² 

[1] Faculty of Science and Technology, Department of Engineering, Aarhus University,Research Centre Foulum, Blichers Allé 20, 8830 Tjele, Denmark

关键词: animal manure;    hydrogen sulfide;    nitrogen;    odor;    ORP;    oxidation curve;    oxygen;    ozone;   

DOI  :  10.3390/s120505349

来源: mdpi

【 摘 要 】

Slurry can be oxidized to eliminate undesirable emissions, including malodorous hydrogen sulfide (H₂S). However, it is difficult to assess the optimal amount of oxidizing agent required. In this study, one cow and one pig manure, each in three particle size ranges were oxidized with 0–350 mg ozone/L manure. Redox and H₂S concentration were measured continuously. During ozonation the manures gave equivalent redox potential curves. A relatively rapid rise in redox potential was observed within a range of −275 mV to −10 mV, with all manures changing as a minimum from −200 mV to −80 mV. The gaseous H₂S emissions were decreased by 99.5% during the redox increase (−200 mV to −80 mV). This is attributed to H₂S oxidation by ozone and oxygen, and is not due to H₂S deprotonation or gas flushing. By identifying the initiation of the final redox level following the rise, the amount of ozone required to remove H₂S from the manure samples was estimated to be in the range of 6–24 mg O₃/L manure, depending on the type of manure. Hence, continuous monitoring of redox potential (termination of the redox rise) during the oxidation treatment is a simple method of achieving cost-effective minimization of H₂S emissions from slurry.

【 授权许可】

CC BY   
© 2012 by the authors; licensee MDPI, Basel, Switzerland