PATTERN RECOGNITION IN FLOW VISUALIZATION AROUND A PADDLE IMPELLER

JOURNAL OF CHEMICAL ENGINEERING OF JAPAN

YOICHI NAGASE¹  SUGENG WINARDI¹  SHUYA NAKAO¹ 

[1] Department of Chemical Engineering, Hiroshima University

关键词: Mixing;    Paddle Impeller;    Visualization;    Flow Recognition;    Impeller Stream;    Conditional Sampling;    Velocity Distributions;    Torque Fluctuations;   

DOI  :  10.1252/jcej.21.503

来源: Maruzen Company Ltd

【 摘 要 】

References(18)Cited-By(17)Very low frequency fluctuations in the velocity signal from several seconds to several minutes in scale are usually observed in agitated vessels. It is shown in this work that these fluctuations result from the abrupt replacement of the flow pattern in the vessel, even in part. Pattern recognition studies of the flow in the impeller region of a paddle were carried out, using high-speed VTR. The results showed that the flow between blades is characterized into five patterns which are replaced one after another. They are classified into the discharge and the cross-pass types of flow. The latter means that flow passes between impeller blades, upwardly or downwardly. The lifetime of the discharge flow type was three times that of the cross-pass flow type. The velocity distributions of the discharge and cross-pass flow types estimated from visualized pictures were quite different from each other and were different from the average distributions obtained by LDV. When the cross-pass pattern had developed over the whole region between blades, a horizontal figure-eight pattern of flow developed in the entire vessel with abrupt reduction of the torque.

【 授权许可】

Unknown