Characteristics and Thermal Behaviour of Low Rank Malaysian Coals towards Liquefaction Performance via Thermogravimetric Analysis

Soft Soil Engineering International Conference 2015

Ishak, M.A.M.^1 ; Ismail, K.^2 ; Nawawi, W.I.^1 ; Jawad, A.H.^1 ; Abdullah, M.F.^1 ; Kasim, M.N.^1 ; Ani, A.Y.^1

Faculty of Applied Sciences, Universiti Teknologi MARA, Perlis-Arau

02600, Malaysia^1

Faculty of Applied Sciences, Universiti Teknologi MARA, Selangor, Shah Alam

40450, Malaysia^2

关键词: Direct liquefaction;    Low rank coals;    Temperature range;    Thermal behaviors;    Thermal behaviours;    Thermal characteristics;    Thermal evolution;    Volatile matters;   

Others  :  https://iopscience.iop.org/article/10.1088/1757-899X/136/1/012089/pdf
DOI  :  10.1088/1757-899X/136/1/012089

来源: IOP

【 摘 要 】

In this study, thermal behaviour of two low-rank Malaysian coals namely Mukah Balingian (MB) and Batu Arang (BA) were obtained under pyrolysis conditions via Thermogravimetric analysis (TGA) at a heating rate of 20°C min-1. The thermal characteristics of the coals were investigated prior to direct liquefaction in order to determine the liquefaction performance, i.e. coal conversion and oil yield. The differential weight loss (DTG) results for both coals showed that there are three main stages evolved which consists of moisture, volatile matter and heavier hydrocarbons that correspond to temperature range of 150, 200-500 and 550-800°C, respectively. Apparently, the DTG curves of BA coal reveals a similar pattern of thermal evolution profile in comparison to that of the MB coal. However, the calculated mean reactivity of BA coal is higher than that of MB, which implied that BA would probably enhance coal conversion and oil yield in comparison to MB coal. Interestingly, results showed that under the same liquefaction conditions (i.e. at 4MPa pressure and 420°C), conversion and oil yield of both coals were well correlated with their reactivity and petrofactor value obtained.